Phone:0086-371-60922096

4T Natural Gas Steam Boiler

4T Natural Gas Steam Boiler

Commissioning of Boiler gas boiler commissioning must be carried out after the hydrostatic test. Before commissioning, should be a comprehensive inspection of each furnace parts, electronic control devices, wiring, etc. are normal, water supply, oil furnace if opened, electrical contacts are in the set position. 1, depending on the size of the fuel consumption, the initial damper, the hydraulic pressure. 2, the power is turned on, the power switch to open the cabinet, the water pump starts furnace, (if the pump is rotated into the anhydrous, pump purge valve is opened, the air exhaust pump). 3, control checks whether the normal water level electrode. 4, check the burner operation is normal. Starter burner starts combustion when the water level rose to a predetermined level, the start of combustion is normal to observe: Start no vibration noise, stable combustion, no smoke, orange yellow flame, burning bright clear. Otherwise, to make the appropriate adjustment (refer to burner instructions). Note: The oil pressure between 0.8 ~ 1.0Mpa, after a good tune, do not easily change, oil pressure is too high or too low have an effect on burner performance life. 5, check the pressure gauge pointer swing is smooth, with or without loosening stuck. 6, whether the discharge check valve is set at the set pressure steam: Pressure controller first maximum working pressure, a safety valve is adjusted to the set pressure higher than 0.05MPa, when the furnace pressure was raised to whether the exhaust pressure setting, if exhaust , pulling the safety valve a few times, and try again, if not enough to deal with safety valve to adjust. Pressure relief valve setting: boiler rated pressure + 0.03MPa. 7, check the electrical contacts of the operation: When the pressure is raised to the maximum working pressure (not exceed the rated working pressure), should stop burning, open the safety valve blowing off steam, the pressure to a minimum operating pressure (maximum operating pressure is generally lowest set to 0.10MPa), combustion burner should be restarted. Note: When the adjustment screw should slow, especially when the pointer approaches the end, otherwise, damage the screw off the wire.

Horizontal 4t steam boiler with a boiler boiler you know take you through a horizontal steam boiler Generally speaking, we use boilers have very many models, according to their different fuels of different works, there are different, the boiler itself institutions, divided into many, the Take the steam boiler, there are still sub-ordinary boilers and steam boilers of it, for this horizontal steam boiler, his characteristics is not the same. Boiler fire resistant concrete arch from ramming. After the arch low and long, and therefore good combustion, flue wings and side wall refractory material sintered brick. Boiler front wall, back wall using a common bricks. Grate air distribution reasonable, the combustion chamber is large, strong coal applicability. Adapt to all types of bituminous coal or anthracite, mixed coal. Full combustion. Since the high temperature flue gas enters the first settling chamber, and then into the wings on both sides of the stack, before the smoke box, smoke and dust so good effect. Water circulation simple, reasonable structure and components under pressure, in the case to ensure water quality, completely safe operation. Combustion equipment for the quick grate, combustion apparatus installed in the manufacturing plant, transported to the site can be directly mounted on a foundation. With a reasonable structure, compact, low consumption of steel, the boiler performance, weight, frame size and capacity of the domestic product has obvious advantages compared. It is a horizontal type boiler quick fire tube boiler, refrigerant natural circulation. The boiler drum from the heat exchange system, the left and right header, composed of the water wall, the main furnace wall with a heating surface, convection tube inner drum portion and the drum.

Successful ignition of fuel 4t steam boiler can not run, because of those common oil gas powered steam boiler applications, all of you should ignite the fuel steam boiler in the application process, no way ignition is also the most common problems. Fuel steam boiler in the application process, most likely resulting in no way ignition, resulting in fuel steam boiler can not run normally, small series to introduce you to a steam boiler does not ignite the fuel to run those common reason. Fuel steam boiler can not run common ignition of those reasons: First, the ignition problems: pulse ignition and control systems such as the one of which has caused the problem, the fuel steam boiler can not start. Second, the battery thing: to be very important to see if the battery is a battery in the end is not too aging. The charge is not standard, the same can not let steam boiler fuel ignition. Third, the water pressure thing: at the inlet steam boiler fuel filters block the formation of water can not flow normally through the clean up clean ok. Fourth, the pulse valve problems: If the boiler ignited fuel vapors to ignite division saw sound, no pulse valve "despair" squeak, probably for the pulse valve is damaged or degraded, pulse valve degeneration, will not manipulate, the beginning of the ignition operation when closing a flow will hit a fire, but the fire immediately and confinement; pulse valve before confirm whether there is a problem to confirm whether normal ignition actuating member, if the fault can not pull the valve actuating pulse. V. ignite feelings needles or needle thing: fuel steam boiler ignited hand shift. You can change or correct the ignition pin arrangement; if feelings of degradation promise things, as long as the feeling wiped clean arranged on it. Six, usually no way to exhaust smoke tube. Smoke tube steam boiler with a fuel block, clean breathing tube blockers smoke tube is too long, the configuration is not correct. Referring may be configured to inform two coaxial cigarette heater tube. VII vapor setter joint problems: fuel steam boilers, water vapor degradation intimal flap valve or joint damage, not the weak control push button switch; weak bad control switch button.

Fast boiler particularly strong technical team, they listened carefully to our needs and give us tailored technology solutions, from boiler production, transport to the site installation and commissioning took only 35 days time, all aspects of the deal in place, the boiler quickly it is put into use. --customer feedback

Contact

Contact Form

Address

Related Information

What You Should Know About Gas Boiler Ventilation

Unfortunately, a lot of them don't even understand why ventilation is so important to make their gas appliances (including gas boilers) work properly. So we would like to mention these reasons here: A certain amount of oxygen is needed to make natural gas burn correctly.

Online chat

China Industrial Commercial Ultro-Low Nox Condensing

Boiler, Steam Boiler, Gas Boiler manufacturer / supplier in China, offering Industrial Commercial Ultro-Low Nox Condensing Diesel Oil Gas Fired Steam Boiler 1 2 Ton 3tons 4t/H 5ton Per Hour 1-25ton Optional with Italy Burner Prices, Steam Generator Biomass 50kg / H Wood Steam Boiler, Vertical Biomass Boiler/Wood Boiler/Sawdust Boiler Manufacture and so on.

Online chat

Industrial Natural Gas Boiler l SIMONEAU | Simoneau

Simoneau Natural Gas Boilers. Natural gas is a viable and economical alternative to heat and process steam generation. Our boilers offer high temperature water heating solutions and generate high quality steam. Whatever your application, we got you covered.

Online chat

PDF New Source Performance Standards Subpart Dc for Boilers

Natural Gas: (1) a naturally occurring mixture of hydrocarbon and non-hydrocarbon gases found in geologic formations beneath the earth's surface, of which the principal constituent is methane, or (2) liquefied petroleum (LP) gas, as defined in ASTM D1835-86, 87, 91, or 97. What Boilers are Subject to the Subpart Dc Standards?

Online chat

Comparison Of Combustion Performance Between Natural Gas

Comparison Of Combustion Performance Between Natural Gas And Medium Fuel Oil At Different Firing Settings For Industrial Boilers Conference Paper (PDF Available) · August 2006 with 2,739 Reads

Online chat

PDF ENERGY STAR Boilers Product List

Manufacturing Ltd. Super Hot Mini-Gas MG-150-P-E Water Propane 86.3 10/12/2010 Allied Engineering Company Div. of E-Z-Rect Manufacturing Ltd. Super Hot Mini-Gas MG-50-N-E Water Natural gas 85.0 10/12/2010 Allied Engineering Company Div. of E-Z-Rect Manufacturing Ltd. Super Hot Mini-Gas MG-50-P-E Water Propane 85.9 10/12/2010 ENERGY STAR Boilers

Online chat

Natural Gas - Boilers - Heaters - The Home Depot

Get free 2-day shipping on qualified Natural Gas, Boilers products or buy Heating, Venting & Cooling department products today with Buy Online Pick Up in Store. Natural Gas - Boilers - Heaters - The Home Depot

Online chat

China Natural Gas Fired Steam Boiler - China Steam Boiler

Steam Boiler, Gas Steam Boiler, Boiler manufacturer / supplier in China, offering Natural Gas Fired Steam Boiler, Ferrosilicon Making Furnace/Ferrosilicon Production Line, Non-Asbestos Fiber Cement Board Production Line and so on.

Online chat

ENERGY STAR Most Efficient 2020 Boilers | Products

ENERGY STAR Most Efficient 2020 Boilers. product line provides a wide range of input ratings from 60K to 120K Btu on the combi and up to 150K Btu on the solo boilers. Fueled with either Natural Gas or Propane our condensing boilers have obtained one of the highest AFUEs (Annual Fuel Utilization Efficiency) in the industry.

Online chat

PDF United States Environmental Protection Agency General Air

Natural gas combustion boilers are used to generate industrial electric power, produce industrial process steam and heat, and heat residential and commercial space. 3. Natural gas is generally more than 85 percent methane with varying amounts of eth ane, propane, butane, and inert gases (typically

Online chat

Chinese Natural Gas or LPG Steam Boiler - China Natural

Chinese Natural Gas or LPG Steam Boiler, Find details about China Natural Gas Steam Boiler, Boiler from Chinese Natural Gas or LPG Steam Boiler - Zhangjiagang Future Boiler Manufacture Co., Ltd.

Online chat

Industrial Natural Gas Steam Boilers | Products

Find Industrial Natural Gas Steam Boilers related suppliers, manufacturers, products and specifications on GlobalSpec - a trusted source of Industrial Natural Gas Steam Boilers information.

Online chat

Package Boilers - Babcock & Wilcox

They are engineered to meet unique capacity, space, fuel, emissions, transportation, installation and other requirements. They offer reliable power with low emissions, low auxiliary power requirements, simple operation, low maintenance and can be tailored for a variety of fuel options, including natural gas.

Online chat

China Steam Boiler manufacturer, Hot Water Boiler, Hot Oil

Steam Boiler, Hot Water Boiler, Hot Oil Boiler manufacturer / supplier in China, offering Wood Autoclave for Wood Treatment Wood Processing Equipment, Instant Steam Source Modular Natural Gas Fired Steam Boiler Steam Generator, WDR Series Electric Heating Steam Boiler and so on.

Online chat

Boilers - Lennox

Ideal for homes in northern regions, Lennox ® boilers integrate easily with existing radiator or under-floor heating systems for energy-efficient comfort, all winter long. With efficiency ratings of up to 95% AFUE, Lennox boilers can help you save hundreds of dollars each year in utility bills, compared to older and standard- efficiency boilers.

Online chat

Project